Material Safety Data Sheet U.S. Department of Labor
Complies with USDL Safety and Health regulations. (29 CFR 1910. 1200)
Section 1: PRODUCT IDENTIFICATION: Degreaser/Deodorant
Orange TKO Industries International
#118 918 - 16th Ave. NW Calgary, AB T2M 0K3
Revision Date: 01/01/08
SECTION II: HAZARDOUS INGREDIENTS
This product contains no ingredients which are considered to represent a health hazard as currently defined by 29 CFR 1920. 1200
This product is not a carcinogen or potential carcinogen as defined by OSHA, The NTP, or the IARC monographs.
SECTION III: PHYSICAL DATA
BOILING POINT: 352 degrees Fahrenheit
VAPOR PRESSURE: 1 mm of HG @ 20 degrees centigrade
VAPOR DENSITY, (Air=1): 4.69
SOLUBILITY IN WATER: Emulsifies; Soluble only in trace quantities.
SPECIFIC GRAVITY, (H20=1): 0.841 @25 Degrees C./25 Degrees C.
PERCENT VOLATILE BY VOLUME: 93%
EVAPORATION RATE, (Water=1): <1
P.H.: (10% Emulsion): 4 - 6
APPEARANCE AND ODOR: Amber liquid with citrus odor.
SECTION IV: FIRE AND EXPLOSION DATA
FLASH POINT, (method used): 120 degrees Fahrenheit, (C.C.)
FLAMMABLE LIMITS, (A.I. 302 degrees Fahrenheit): LEL-0.7; VEL-6. 1
EXTINGUISHING MEDIA: 1) Dry powder; 2) Foam; 3) C02
SPECIAL FIREFIGHTING PROCEDURES: Avoid use of water as it may spread flame.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Combustible liquid. Keep away from sparks and open flame.
SECTION V: HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: Unknown
EFFECTS OF OVEREXPOSURE: Direct eye contact will result in irritation. Possible skin irritation with prolonged use.
EMERGENCY FIRST AID PROCEDURES:
SKIN: Wash immediately with soap and water.
EYES: Flush with water, if irritation persists, call physician.
INGESTION: Drink large volumes of milk or other liquid, call physician immediately.
INHALATION: If symptoms of overexposure and experienced, evacuate to fresh air. Consult physician if breathing is difficult.
SECTION VI: REACTIVITY DATA
STABILITY DATA: Stable
INCOMPATIBILITY: Avoid strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: None known.
HAZARDOUS POLYMERIZATION: May occur. Polymerization catalysts such as aluminum chloride should be avoided.
SECTION VII: SPILL OR LEAK PROCEDURES
SMALL SPILLS: Wipe up product, rinse soiled area with water down the drain.
LARGE SPILLS: Stop leak at the source and collect into a suitable container, then treat as a small spill.
Follow state and local regulations for disposal of large non-reclaimable spills.
SECTION VIII: SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: Not normally required, but if vapor concentration becomes high, use general purpose organic vapor mask.
VENTILATION: Local exhaust should be adequate.
PROTECTIVE GLOVES: Nonporous rubber gloves.
EYE PROTECTION: Chemical splash goggles or face shield.
OTHER PROTECTIVE EQUIPMENT: Usually not required.
SECTION IX: SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Handle as a combustible liquid. Vapors can ignite, store away from heat and open flame. Always store unused portion in original container with cap secure. Avoid temperature extremes.
OTHER PRECAUTIONS: All handling equipment should be electrically grounded. As with all chemicals, use with due care according to label instructions and precautions.